|
|
| *Vultures Knob>>>Bike Lights |
Motorbike will not start.ever.? |
i have a Honda CM125 four stroke with CDI. the bike was having trouble starting-just clicked under the seat and didn't crank- but bump started fine. i put WD40 on the contacts- ran perfectly. 10miles in it stopped. it wouldn't bump start.lights ect. work, KILL switch is on RUN, fresh fuel, checked contacts, fuel lines ect....NO STARTER. it cranks but won't fire. but the spark plugs fires.it smells of fuel. it wont bump start. i replaced the spark plug and battery, and coil, and CDI unit-no difference. ps.the bike doesn't have points. You obviously have a starter problem ie starter drawing too much current or dirty comutator , this explains your click to start with made by solinoid, and when it finally cranks you cannot get it to fire , weak spark. remove your starter and overhaul ie.. new brushes and clean up or recut comutator on starter armature this should increase power to plugs which should give better spark and make it go Source(s): A grade motorcycle engineer 35 years in trade you are not getting a spark for some reason. Sounds tobe a wiring issue. You need to back test the system. Use a Ohm. Meter. Check all wires. I bet one is grounded out or is corroded Does it have a choke and if it does, are you sure you are engaging it correctly. Sounds too simple, but sometimes the silly things can drive you crazy. Similar experience with '91 zx-6 years ago. Check all your safety switches and fuses , I had a kickstand with a safety switch and it was hanging down just enough to make bike not start god bless |
| Tags |
| Bike Tours Trail Map Bike Pedals Bike Lock Bike Lights Bike Helmet Quad Bike Pocket Bike Mini Bike |
Bike Categories--Copyright/IP Policy--Contact Webmaster |